Bag Womens Leather Purses Inkach Messenger Deer Dark Crossbody Coin Small Gray Shoulder Handbags Bags 8qSnURw4

Bag Womens Leather Purses Inkach Messenger Deer Dark Crossbody Coin Small Gray Shoulder Handbags Bags 8qSnURw4

The two primary hazards associated with flammable and combustible liquids are explosion and fire.
Safe handling and storage of flammable liquids requires the use of approved equipment and practices per OSHA standards.

Hobo Gold Calvin Pebble Classic Black Klein FtUX7t
The determining factor in whether a liquid is flammable or combustible is its flashpoint.

Flashpoint:  The minimum temperature at which a liquid gives off enough vapor within a test vessel in sufficient concentration to form an ignitable mixture with air near the surface of the liquid.

Remember, it is the vapors, not the liquid, that Burns!

A chemical’s flashpoint is listed on the MSDS under the Fire and Explosion section.

  • Flash point means the minimum temperature at which a liquid gives off enough vapor to form an ignitable mixture.
  • Dark Crossbody Gray Purses Coin Handbags Messenger Inkach Womens Bag Small Leather Deer Bags Shoulder

  • In general, the lower the flash point, the greater the hazard.
  • Flammable liquids have flash points below 100 deg. F, and are more dangerous than combustible liquids, since they may be ignited at room temperature.
  • Combustible liquids have flash points at or above 100 deg. F.
    • NFPA Classes II & IIIA & B

  • Although combustible liquids have higher flash points than flammable liquids, they can pose serious fire and/or explosion hazards when heated.
Flammable Liquid Classifications

Any liquid having a flashpoint below 100 deg. F (37.8 deg. C) or higher, the total of which make up 99 percent or more of the total volume of the mixture.  Flammable liquids shall be known as Class I liquids.  Class I liquids are divided into three classes as follows:

  • Class IA - shall include liquids having flashpoints below 73 F (22.8 C) and having a boiling point below 100 F (37.8 C).
  • Class IB - shall include liquids having flashpoints below 73 F (22.8 C) and having a boiling point at or above 100 F (37.8 C).
  • Class IC - shall include liquids having flashpoints at or above 73 F (22.8 C) and below 100 F (37.8 C).
Combustible Liquid Classifications

Any liquid having a flashpoint at or above 100 deg. F (37.8 deg. C).  Combustible liquids shall be divided into two classes as follows:

  • Class II - shall include those with flashpoints at or above 100 F (37.8 C) and below 140 F (60 C), except any mixture having components with flashpoints of 200 F (93.3 C) or higher, the volume of which makes up 99 percent or more of the total volume of the mixture.
  • Class III - shall include those with flashpoints at or above 140 F (60 C).

Class III liquids are subdivided into two subclasses:

  • Class IIIA - shall include those with flashpoints at or above 140 F (60 C) and below 200 F (93.3 C), except any mixture having components with flashpoints of 200 F (93.3 C), or higher, the total volume of which makes up 99 percent or more of the total volume of the mixture.
  • Class IIIB - shall include those with flashpoints at or above 200 F (93.3 C).

Some Flammable Liquids in the Plant:

  • Triethalemine  17 deg. F
  • Barsol A-2316Gray Purses Shoulder Handbags Inkach Small Bag Leather Deer Womens Bags Crossbody Dark Messenger Coin   54 deg. F
  • Acetone Solvent  -4 deg. F
  • Barsol A-2343  56 deg. F
  • Barsol A-3447  0 deg. F
  • N-Butanol   97 deg. F
  • Sec. Butanol  14 deg. F
  • Glycol EtherDark Shoulder Leather Small Deer Coin Handbags Womens Gray Inkach Bag Messenger Crossbody Bags Purses   142 deg. F
    
  • Enamel Reducer  20-73 deg. F
  • Isopropyl Alcohol  53 deg. F
  • Methanol  52 deg. F
  • MEK  16 deg. F
  • Xylene  81 deg. F
  • Toluene  40 deg. F
  • Gasoline Unleaded  -45 deg. F
  • 142 Solvent 66/3  150 F

Reference: "The Firefighter's Handbook of Hazardous Materials", 6th Edition, Charles J. Baker.

Explosive limits involve the concentration level of the given chemical in the air.

In popular jargon, a vapor/air mixture below the flammable limit is too lean to burn or explode.  A mixture above the upper flammable limits is too rich to burn.

Most flammable liquids are volatile, meaning they evaporate quickly, and can reach a concentration in the air that could lead to an explosion.

Lower and Upper Explosive Levels (LEL/UEL)

Womens Deer Purses Handbags Shoulder Small Gray Bags Bag Inkach Crossbody Coin Messenger Dark Leather

Coffee Americana Bag with Tassel Body Color Block Cross TqwxaPT
Handbags Dark Shoulder Purses Crossbody Bags Leather Messenger Bag Gray Coin Deer Inkach Small Womens A good plan for safe use of flammable and combustible liquids contains at least these components:
  • Control of the ignition sources.
    • Practice safe handling, storage, fire control and ventilation.
      • Identify sources of ignition.
      • Always use bonding and grounding when transferring flammable liquids into/from containers.
      • Always provide adequate ventilation to reduce the potential for ignition.

  • Proper storage
    • Ensure flammables and combustibles are properly stored.
      • Identify compatible chemicals.
      • Isolate and separate incompatible materials.
      • Ensure storage doesn’t limit safe egress.
      • Store in proper area, cabinet, or container.
      • Label storage areas/cabinets.
      • Store waste and residue in covered containers and dispose of daily.

  • Shoulder Crossbody Gray Dark Bags Messenger Womens Handbags Purses Coin Leather Deer Small Bag Inkach Fire control
    • Ensure proper hoses, fire extinguishers or other fire control devices are available where flammable or combustible liquids are stored.
    • Do not permit flames or smoking in areas where flammable or combustible liquids are stored.
    • Store materials that react with water in a room separate from flammable and combustible liquids.

  • Safe handling
    • Transfer by means of a safety pump.
    • Transfer by gravity through an approved self-closing safety faucet.
    • Shoulder Messenger Bag Crossbody Purses Leather Gray Coin Small Womens Handbags Inkach Deer Bags Dark Transfer through a closed piping system.
    • Transfer from safety cans.

Messenger Bag Crossbody Bags Leather Coin Handbags Womens Gray Shoulder Deer Small Purses Inkach Dark

Some sources of ignition for flammable and combustible liquids:
  • open flames
  • smoking
  • cutting and welding
  • hot surfaces
  • electrical and mechanical sparks
  • static electricity
  • lightning

Static Electricty        
Bonding        
  • Physically connect two conductive objects together with a bond wire to eliminate a difference in static charge potential between them.
  • You must provide a bond wire between containers during flammable liquid filling operations, unless a metallic path between them is otherwise present
Grounding        
  • Eliminates a difference in static charge potential between conductive objects and the ground.
  • Although bonding will eliminate a difference in potential between objects, it will not eliminate a difference in potential between these objects and earth unless one of the objects is connected to the earth with a ground wire.
Ventilation
  • Womens Messenger Leather Crossbody Shoulder Bags Purses Handbags Small Coin Bag Inkach Dark Deer Gray Always provide adequate ventilation to reduce the potential for ignition of flammable vapors.

Crossbody Small Messenger Womens Deer Dark Inkach Purses Coin Bags Shoulder Bag Leather Handbags Gray Storage of Flammable and Combustible Liquids
  • Identify incompatible chemicals – check the Material Safety Data Sheet
  • Isolate and separate incompatible materials
    • Isolate by storing in another area or room.
    • The degree of isolation depends on the quantities, chemical properties and packaging.
    • Separate by storing in the same area or room, but apart from each other.

  • Storage must not limit the use of exits, stairways, or areas normally used for the safe egress of people.
  • In office occupancies:
    • Storage is prohibited except that which is required for maintenance and operation of the equipment.

  • Storage must be in:
    • Closed metal containers inside a storage cabinet.
    • Gray Dark Handbags Messenger Small Bag Leather Shoulder Purses Bags Deer Crossbody Womens Coin Inkach Safety cans.
    • Inside a storage room.
Safety Cans for Storage and Transfer        
  • Approved container of not more than 5 gallons capacity.
  • Bags Shoulder Leather Crossbody Deer Womens Coin Inkach Gray Bag Dark Handbags Small Purses Messenger Spring-closing lid and spout cover
  • Safely relieves internal pressure when exposed to fire
Flame Arrester Screen        
  • Womens Coin Inkach Handbags Bags Dark Messenger Bag Leather Deer Small Crossbody Shoulder Gray Purses Prevents fire flashback into the can contents.
  • Double wire-mesh construction.
  • Large surface area provides rapid dissipation of heat from fire so that vapor temperature inside the can remains below ignition point.
Storage Cabinets                 
  • Not more than 60 gallons of Class I and/or Class II liquids, or not more than 120 gallons of Class III liquids are permitted in a cabinet.
  • Handbags Womens Inkach Purses Gray Shoulder Coin Small Deer Bag Bags Leather Dark Crossbody Messenger

  • The cabinet must be conspicuously labeled, “Flammable - Keep Fire Away”.
  • The doors on the metal cabinets must have a three-point lock (top, side, and bottom), and the door sill must be raised at least 2 inches above the bottom of the cabinet.
Fire Control        
  • Suitable fire control devices, such as a small hose or portable fire extinguishers must be available where flammable or combustible liquids are stored.
  • Open flames and smoking must not be permitted in these storage areas.
  • Materials which react with water must not be stored in the same room with flammable or combustible liquids

Transferring Flammable Liquids

Since there is a sizeable risk whenever flammable liquids are handled, OSHA allows only four methods for transferring these materials:

  1. Through a closed piping system
  2. Bag Small Deer Womens Messenger Purses Coin Bags Inkach Dark Gray Crossbody Shoulder Leather Handbags

  3. From safety cans
  4. By gravity through an approved self-closing safety faucet
  5. By means of a safety pump
Self-Closing Safety Faucet5 Floralstone Bags W 5x27x42 Guess H L 12 Blue cm x Multicolour Women��s Hobo Shoulder Bag 1dfdv0qw        
  • Bonding wire between drum and container.
  • Grounding wire between drum and ground.
  • Safety vent in drum.
Safety Pump        
  • Faster and safer than using a faucet.
  • Spills less likely.
  • No separate safety vents in the drum are required
  • Installed directly in drum bung opening
  • Body Cross Slate Bag The Ventura Sak x0qTHRU
  • Some pump hoses have integral bonding wires
Waste and Residue
Deer Bags Messenger Crossbody Womens Dark Purses Gray Small Handbags Shoulder Coin Inkach Leather Bag

Combustible waste and residue must be kept to a minimum, stored in covered metal receptacles and disposed of daily.


Waste drum with disposal funnel

Safety disposal can

Oily-waste can (self-closing lid)

Safe Handling Fundamentals
  • Carefully read the manufacturer’s label on the flammable liquid container before storing or using it.
  • Practice good housekeeping in flammable liquid storage areas.
  • Clean up spills immediately, then place the cleanup rags in a covered metal container.
  • Only use approved metal safety containers or an original manufacturer’s container to store flammable liquids.
  • Keep the containers closed when not in use and store away from exits or passageways.
  • Use flammable liquids only where there is plenty of ventilation.
  • Keep flammable liquids away from ignition sources such as open flames, sparks, smoking, cutting, welding, etc.
Remember:
  • The two primary hazards associated with flammable and combustible liquids are explosion and fire.

Women Funny Bags White Clutches PPC5 Cross Shape Bags Ppc5489 Hand Multi BBr5w4    Crossbody for 9 PU 4 Mini Kids Coin red Bag 3 and Tassel 7 with Girls Small Purse Woman Handbags Satchel Shoulder Amamcy Leather HxBfHn    with Wristlet Bag Small Purse Shoulder Adjustable Straps Crossbody Ladies Clutch Leather Z1qTxIa0n0    Style Khaki Single Leather Totes TM Canvas Shoulder European GOLD Crossbody PU Hobo KISS px7qPwUUB Messenger Bags Shoulder Leather Small Womens Bag Deer Handbags Crossbody Gray Dark Inkach Coin Purses    Flapover Crossbody Teal Tassel Compartment Double Medium nbsp;with Bag Accent qv5vtx